Representative image of a green alfalfa farm field (Image Credits: Pexels)
Representative image of solar panels on a farm. (Image Credits: Pexels) Fuel savings and the limits of the model According to the USDA , the project received a $253,405 grant through the Rural Energy for America Program. During its first full year of operation, it achieved 223,400 kilowatt-hours in solar mode and saved 16,385 gallons of diesel. Since the solar irrigation system became operational in late April 2019, Dunn told Ag Proud, it had missed the opportunity to use its harnessed power for pre-irrigation during the preceding winter. In its first year, the solar system reduced the requirement for diesel by 60%, and the model’s performance suggested 70% savings could be realised, a figure that Dunn believes could go up to 75% under the right conditions. Solar remained financially feasible when compared to diesel, which cost $2.15 per gallon in October 2019 before rising to between $2.30 and $2.40, and Dunn cautioned that the economics may vary from one farm to another.
Dunn used solar modelling to estimate electricity generation and the available hours for pumping before committing to the project. He had also planned to irrigate whenever sunlight and temperatures allowed, while storing water in the soil for crop use. The output of solar energy was contingent on weather and temperature, as higher temperatures reduced panel performance whereas cloud cover lowered solar generation, consequently increasing the need for diesel backup. Dunn reports that from around October to mid-May, the system functioned mainly on solar, with the diesel generators supplementing the system during summer. This delayed start thereby limited the system’s contribution and left the farm dependent on its existing diesel-powered equipment. However, these estimates were only projections, not a verified number. For operations with substantial energy demand throughout the year, it would be more beneficial than for farms at high altitudes with short growing seasons. In the end, the project proved that solar power can reduce diesel dependence where grid electricity is unavailable, but it did not eliminate the need for fuel. You use AI every day. Now get your AI Quotient. Take the AIQ test.
An alfalfa farmer reduced the use of diesel by 16,385 gallons in 2019 after installing solar-powered irrigation at his off-grid farm. The Railroad Valley Farms in Nye County, Nevada, paired solar photovoltaic (PV) arrays with diesel generators for the irrigation of 500 acres of alfalfa, according to the U.S. Mark Dunn, the farm’s operator, believes that this hybrid setup will save about $1 million over its lifetime. The farm sits at roughly 4,900 feet above sea level, where the area only receives five to six inches of annual precipitation. The first installation used variable-speed drives and solar arrays to track the sun and power four quarter-mile centre pivots that irrigated 500 acres of alfalfa, according to Ag Proud. With calculated spacing between them, the panels were arranged in a way to prevent one from shading the other while two 325-kilowatt direct-current arrays supplied 175-kilowatt alternating-current systems.
Department of Agriculture (USDA). Alfalfa production depends on groundwater and powered irrigation, but no electrical grid was connected to the farm; instead, it relied on diesel to pump water and operate its irrigation systems. Why the farm used both solar and diesel A viable alternative was available through Solar power; however, it couldn’t meet the required round-the-clock irrigation since it couldn’t function beyond daylight hours. In response, Dunn adopted a hybrid arrangement in which solar provided most of the energy demand and the diesel generators functioned as automatic backup in case the output were to fall short.